UltraTough M&I High Speed Rubber Door

UltraTough comes standard without springs on sizes up to approximately 30'x30'. Competitive rubber doors often utilize a complicated combination of springs, sprockets, chains and reducers to help lift the door.

Not UltraTough! Instead UltraTough utilizes a direct drive motor and a frequency converter. The soft start and stop design eliminates shock and wear to the gear box. Our direct drive is simple yet strong.

Maintenance costs are reduced dramatically with UltraTough.

Warranted for the life of the door, the thick two layer SBR and high tensile strength polyester fabric provides superb resiliency in harsh environments.

These high speed doors offer more protective sensors than anyone in the industry. As a result, the risk of injury to people and damage to vehicles is reduced significantly.

One of the most common causes of injury or damage to vehicles is when a door comes down on a person and hits them in the head or face. This is often the result of photo eyes being improperly installed, or worse, not installed at all.

The TruckGuard Safety System offers a full curtain of protection up to approximately six feet high on both sides of the door. As a result, loads cannot go below or through the beams without being detected. Once an object is detected, the door automatically retracts.

No door is as safe as the ones we sell.

The UltraTough Seals great. UltraTough's patented wind-lock system is a ½" rubber extension that runs the full length of the door curtain. When the heavy duty front channel is closed, the wind-lock is secured tightly. No premature break-outs.

There is no better seal than with UltraTough. As pressure is put on the door area the door panel locks into place. The more pressure, the better the seal yet the door will still operate smoothly.

UltraTough uses high strength structural steel throughout the door. Our UltraTough's optional self-supporting design eliminates stress on building walls and makes installation much simpler and quicker to perform.

When it comes to Beef, long life, and low cost of ownership think UltraTough.

The UltraTough's Digital Gateway Controller is people friendly and intuitive, making door operation effortless.

All of our high speed doors come standard with an exclusive patent pending and fully modular UltraSmart Controller.

In the event of a problem, the UltraSmart Controller diagnoses it and recommends a solution. If the door is impacted and breaks away, the Controller walks the operator through all the steps required to fix the door quickly and without hassle.

The UltraClean UltraSmart control box comes standard with an integrated rotary disconnect.

The new wireless safety system is revolutionary.

Most high speed doors in operation today use coil cords.  The problem with coil cords is they:

• Get tangled up
• Catch on other objects
• Are susceptible to breakage
• Are difficult and costly to repair
• Tend to stretch and sail into the photo eyes causing false activation

Cut your cord with ASP's Wireless Safety System and all of these common problems are eliminated.